How Much Does a Heat Pump Cost in Crab Orchard?

$28/hr

Local HVAC Labor Rate

Labor is the biggest variable between cities. The Bureau of Labor Statistics reports that HVAC installers in the Crab Orchard area earn a median of $28/hr. After business overhead (insurance, trucks, office), contractors typically charge around $98/hr. A typical install takes a 2-person crew 8–12 hours, putting Crab Orchard labor at $1,176–$1,960. That's near the national median of $28/hr.

Source: BLS Occupational Employment Statistics, SOC 49-9021

Zone 5

Your Climate Zone

Crab Orchard is in IECC Climate Zone 5. Zone 5 has cold winters with regular temps below 10°F. Heating dominates. Cold-climate models maintain 70–80% capacity at 5°F. This affects what size and type of system you need: since winters are harsh, your system needs enough heating power to keep up without backup electric heat.

A Crab Orchard home under 1,500 sq ft typically needs a 2-ton system ($4,980–$9,068), while homes over 3,500 sq ft need 5 tons ($8,568–$14,852).

In Zone 5, NEEP-certified cold climate models are strongly recommended. These cost 10–20% more upfront but work efficiently down to -15°F, so you avoid expensive backup electric heat strips.

Source: IECC 2021 Climate Zone Map · NEEP Cold Climate Air Source Heat Pump List

9.6¢/kWh

Your Electricity Rate

This is what you pay per kilowatt-hour of electricity through Norris Public Power District. It matters because a heat pump runs on electricity — so your electric rate directly affects how much it costs to heat and cool your home. Your rate is well below average — even a standard-efficiency system will be cheap to run.

What's SEER2? It stands for Seasonal Energy Efficiency Ratio — think of it like MPG for your car. A 20 SEER2 system uses about 25% less electricity than a 15 SEER2 system. At Crab Orchard's rate, that's roughly $164/year saved on heating alone.

Source: EIA Electric Power Monthly · Norris Public Power District

How much does a heat pump cost in Crab Orchard?

A typical 3-ton heat pump installation in Crab Orchard costs $6,176–$10,960, including the equipment, labor, and materials. Costs vary with home size and system type.

What rebates are available in Crab Orchard?

The federal 25C tax credit (up to $2,000) expired December 2025. No active state or utility programs found for this area.

Do heat pumps work in Crab Orchard's climate?

Yes. Crab Orchard is in Climate Zone 5. Zone 5 has cold winters with regular temps below 10°F. Heating dominates. Our recommendation: NEEP-listed cold-climate model with COP above 2.0 at 5°F.

What's the difference between ducted and ductless?

A ducted heat pump connects to the air vents already in your walls and ceiling — if you have a furnace now, you probably have ducts. It heats and cools the whole house through those vents. A ductless mini-split uses small wall-mounted units in individual rooms, connected by a thin pipe to an outdoor unit. It's ideal if you don't have existing ductwork, or want to control temperatures room-by-room.

What does electricity cost in Crab Orchard?

9.6¢/kWh (Norris Public Power District). That's well below the national average — heat pumps are especially cheap to run here. This rate directly affects your monthly operating cost since heat pumps run on electricity.